However, you should know that the circuit breakers will reset themselves and allow the electrical parts to work again once the overload on the circuit is removed. Remove retaining bolt and remove oil pump and intermediate shaft. Pull off the road as soon as it is safely possible. Use care to prevent damage to bearing surfaces. The Vulcan V6 was the only engine for the 1988-1989 Ford Aerostar.
Unsourced material may be challenged and. Carefully disconnect electrical connections to each fuel injector and remove fuel charging wiring 9D930 from engine. Then, pull the belt out and let it retract several times to make sure that the belt works properly. Flywheel Ring Gear Lateral Runout T. Start engine and check for oil leaks. Do not allow people to ride in any area of your vehicle that is not equipped with seats and safety belts. .
Install and adjust drive belt to specification. Thread the lug nuts on the wheel studs with the beveled face toward the wheel. To save space, the live rear axle was fitted with a three-link coil-sprung rear suspension similar to the Panther-platform cars of the time. The rear seat radio controls are located behind the driver on the left hand side of the vehicle. In its stored position, the transmitter can be activated by pressing on the compartment door. Check under the vehicle for leaking fuel.
Piston Specifications Item Specification Diameter Coded Red 88. Imported into North America since 2010, the front-wheel drive Transit Connect is also offered in passenger configurations; a 2014 redesign led to the first seven-seat Ford minivan since 2007. Remove camshaft thrust plate bolts and camshaft thrust plate 6269. This will align the thrust surfaces of both halves of the bearing. Remove the negative cable from the booster battery. Rotate crankshaft 6303 to position camshaft lobe s straight down and away from push rods.
For best results, use the following, or products of equivalent quality: A wide selection of accessories is available through your local authorized dealer. Your air conditioner and heater heats or cools your vehicle interior depending on the function and the temperature you select. In response, Ford announced it would sell both the Aerostar and Windstar vans for the upcoming future. Use it only when you get a flat tire and replace it as soon as you can. Start the piston pin in the piston and connecting rod this may require a very light tap with a mallet.
Tighten the bolts to 14 Nm 10 lb-ft. In 1988, the company commenced design work on a successor to the Aerostar for a planned 1993 introduction. Make sure that the jumper cables are not in the way of moving engine parts, then start the booster vehicle. Connect transmission oil cooler lines to fittings on case and install oil cooler lines. If right cylinder head was removed, perform the following: a. Occasional brake squeal during light to moderate stops does not affect the function of the brake system and is normal. This damage could allow the wheels to come off while the vehicle is being driven.
Install water thermostat 8575 into water hose connection. Pulling by hand can damage the cable. To make sure your tires wear evenly and last longer, rotate them as indicated in the following diagram. Remove the torque converter dust cover retaining bolts and remove the cover. Failure to follow these instructions may increase the risk of personal injury in the event of a collision. The front passenger seat cannot be adjusted.
Even with the Anti-lock Brake System, you should be careful when braking. Remove throttle body, refer to Section 03-04B 12. Two running prototypes were built from the collaboration of Ford and Ghia; both used the stock 3. After starting, allow the engine to idle for a few seconds before driving away. Valve Stem to Guide Clearance Intake 0.
Install new stabilizer bar link nuts and tighten to 16- 24 Nm 12-18 lb-ft. Do not use paper towel or an abrasive cleaner to clean the lens as these may cause scratches. To raise a rear wheel, place the jack under a horizontal portion of the underbody member ahead of the wheel as shown. As the Ford Windstar was being readied for a 1995 model-year introduction, 1994 was set to be the final year for the Aerostar. The player operates when the power is on and a disc is inserted label side up.
The system shifted traction to the front wheels as it detected rear wheel spin, with no driver input required. Oil level indicator tube must bottom out as illustrated. The use of leaded fuel is prohibited by law and could damage your vehicle. In 1989, the chrome grille was replaced by a black-trim grille; the bracketed towing mirrors were replaced by integrated powered sideview mirrors. Rotate crankshaft journal to bottom of its travel if moved.